Other what have u done on ur disco today
- Thread starter gstuart
- Start date
This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
Co-Pang-Yang
Well-Known Member
- Posts
- 2,930
- Location
- Colchester, Essex
Went poking about under the van with a screw driver last week.
Never a good idea
Time so like this I wish I knew how to weld.
Or had the time away from work to learn how to weld!
Never a good idea
Time so like this I wish I knew how to weld.
Or had the time away from work to learn how to weld!
andy85
Active Member
- Posts
- 336
- Location
- Scarborough
Iv just had same happen to mine,just repaired it yesterday
- Posts
- 68,233
- Location
- The Wooly Witch
Went poking about under the van with a screw driver last week.
Never a good idea
View attachment 128251 View attachment 128252 View attachment 128253 View attachment 128257
Time so like this I wish I knew how to weld.
Or had the time away from work to learn how to weld!
I have seen that wire brushed off and covered with flash banding and underseal until the pennies have been squirreled for welding ...
Co-Pang-Yang
Well-Known Member
- Posts
- 2,930
- Location
- Colchester, Essex
Yer I've seen a lot worse too. Just trying not to bodge this one and actually make it nice
Magicgrotto
Well-Known Member
- Posts
- 2,769
- Location
- doncaster
- Posts
- 6,395
- Location
- North Perthshire
Had steering box and pipes changed. Ordered new battery, as apparently the old one was fizzing!Ordered a new (recon) steering box
The joys!
Co-Pang-Yang
Well-Known Member
- Posts
- 2,930
- Location
- Colchester, Essex
Think my steering box is leaking.
Got a dry 200tdi one kicking about that I'm hoping I can put a new seal kit on and get it to fit my 300tdi disco
Got a dry 200tdi one kicking about that I'm hoping I can put a new seal kit on and get it to fit my 300tdi disco
Marmaduke
Well-Known Member
- Posts
- 9,773
- Location
- Near the land of 'Me Duck'
Engine oil, gearbox and transfer box oils. Which ever crap hat put the drain hole for the gearbox right above the cross member wants a slap
Got to see all the lights on the dashboard come on one after another, in the following order, whilst driving from Canterbury to Deal.... battery charge light > Rear Air Suspension Light (both) > Three Amigos > SRS Airbag > S+M. Then they all went off at once, which was a relief, until I realised the temp gauge, fuel gauge, tachometer and speedo had all gone off too..... but that was OK as a moment later the engine stopped. And then nothing worked, except my AA App on the iPhone. Top AA Man out, and confirmed my fear that the alternator had fried itself. The tests showed a 95amp leak to earth from what remained of the cooked battery via the alternator.
Fair play though, he disconnected the alternator and made cables safe, and dropped in a new charged battery so we could drive to a garage and pick up a loan car as I had to get stuff done today. So looks like I'm in the hole for a new alternator....... but on the upside, doesn't appear to have zapped anything else in the process!
Fair play though, he disconnected the alternator and made cables safe, and dropped in a new charged battery so we could drive to a garage and pick up a loan car as I had to get stuff done today. So looks like I'm in the hole for a new alternator....... but on the upside, doesn't appear to have zapped anything else in the process!
- Posts
- 83,282
- Location
- Embasinga stocæ
new battery delivered
Silverbeard50
Member
- Posts
- 99
- Location
- Bristol
This week, I have started on a long list of jobs that has been building up for several months. The back strip down was finished today and the chassis steam cleaned; there's surface corrosion but nothing worse.
From the back:
I would like to sort out the radio/CD player. Somebody has replaced the original unit with a Clarion CD/radio and only connected the two front door speakers. It looks like the plugs have been chopped around so could be fun. I need to find replacements for the two (sub-woofers?) speakers in the back door as these are falling apart. is it possible to buy straight replacements?
From the back:
- Remove boot floor to replace fuel pump and feed and return pipes as necessary - I have been getting a 'fuel pressure' fault on my Hawkeye despite the running pressure being on spec.
- Replace rear brake pipes and flexible hose.
- Remove and recover headlining
- Possibly replace all road springs with new standard OE spec ones. Mine feel very hard after twenty two years; shockers have been replaced.
- remove engine (163K) and replace with low mileage (30K) factory rebuilt unit
- replace both complete front inner wing assemblies whist the engine is out
I would like to sort out the radio/CD player. Somebody has replaced the original unit with a Clarion CD/radio and only connected the two front door speakers. It looks like the plugs have been chopped around so could be fun. I need to find replacements for the two (sub-woofers?) speakers in the back door as these are falling apart. is it possible to buy straight replacements?
Attachments
brian47
Well-Known Member
- Posts
- 8,867
@Silverbeard50
I can't help with the rest of your list, but I can tell you that in the original set up of the radio system, all four door speakers were driven straight from the radio head unit and the two sub-woofers in the tailgate were driven by their own separate amplifier also built into the unit housing the two speakers.
It's unlikely that you'll find a way to get the dashboard controls to work without some serious work and preferably a replacement head unit.
If you do go for a more up-to-date radio unit, you'll find some with front and rear speaker outputs quite easily these days.
Replacement amplifier/speaker units for the rear door do sometimes turn up on ebay.
Wiring drawings for the radio, including wire colour coding can be found in RAVE:-
http://www.green-oval.com/data/lr/rave03.iso
I can't help with the rest of your list, but I can tell you that in the original set up of the radio system, all four door speakers were driven straight from the radio head unit and the two sub-woofers in the tailgate were driven by their own separate amplifier also built into the unit housing the two speakers.
It's unlikely that you'll find a way to get the dashboard controls to work without some serious work and preferably a replacement head unit.
If you do go for a more up-to-date radio unit, you'll find some with front and rear speaker outputs quite easily these days.
Replacement amplifier/speaker units for the rear door do sometimes turn up on ebay.
Wiring drawings for the radio, including wire colour coding can be found in RAVE:-
http://www.green-oval.com/data/lr/rave03.iso
Silverbeard50
Member
- Posts
- 99
- Location
- Bristol
Thanks Brian. I have Rave on my laptop already thanks. The wiring seemed to be a mess last time I had the radio unit out but I hope to sort it out. I suspect that the Clarion unit currently fitted has the outputs that I need. Plenty of time to play with it whilst it's off the road for the rest of the work.
neilly
Well-Known Member
- Posts
- 20,000
- Location
- Oxfordshireness
Taxed it, which I think it does not deserve after it messed me around last week on the motorway.................
But then again, after the new filter housing it is now behaving itself, so maybe I will let it off.
Cheers
But then again, after the new filter housing it is now behaving itself, so maybe I will let it off.
Cheers
andy85
Active Member
- Posts
- 336
- Location
- Scarborough
Got rid of it lol
biketeacherdave
Well-Known Member
- Posts
- 4,885
- Location
- south east london
Fixed and refurbed one of the key fobs
cfwnotloB
Well-Known Member
- Posts
- 4,219
- Location
- Luton Bedfordshire
biketeacherdave
Well-Known Member
- Posts
- 4,885
- Location
- south east london
Does that really count
Of course it does I used a screw driver and soldering iron.......that's proper fixing that is
