nothing coming out of fuel filter drain???

This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
Mudstyler

Mudstyler

Well-Known Member
Posts
179
Location
Hants
Help please.
As part of my long running air in fuel issue, I notice with the pump running, nothing comes out of the water drain when I open it. and if I then remove the air bleed back hose and the brass fitting with the check valve in, still nothing..... Is that right?
 
Mudstyler said:
Help please.
As part of my long running air in fuel issue, I notice with the pump running, nothing comes out of the water drain when I open it. and if I then remove the air bleed back hose and the brass fitting with the check valve in, still nothing..... Is that right?
Click to expand...
I have just removed the drain plug from the filter on mine and can confirm that there was a good steady flow from the filter with the pump running. I didn't remove the air bleed though.
You don't say how long the engine runs clean before giving problems.
Tim
 
Pretty much the normal with them once they have been on the truck a while, a bit of something always blocks them. Not much point in them in my opinion.
If having problems with water in fuel fit a proper sediment filter. Single Fuel Filter Sediment Bowl Assembly Water Separator 1/2" UNF 5836B120 | eBay A clear section of line where fuel line reaches engine bay will find if any air is getting in at the tank/pump end [ electric pump?] of the system.
 
Last edited:
I just noticed the rubber duck bill non return was on the HP return not the LP feed. now getting a dribble through and some venting at the air bleed. purged the system for 30mins till the pump was quiet. did a quick 5 mile run, felt a bit lumpy and when I returned the pump is screaming again. I have a new duck bill and filter on its way....
 
A clear section of pipe where the fuel line arrives in engine bay will tell if air is getting in at tank/pump end of system.
Had a lot of trouble with my car recently with air getting in the system now and then, turned out to be the input connection at the fuel fuel filter. What was happening I recon was when running not enough air getting in to cause any more than the odd hiccup but when stopped sometimes it would be sucked in while stopped as fuel drained back to the tank. Ford Focus that has air locked is a bar steward to bleed.:mad: New joint fixed it.:)
 
tottot said:
Pretty much the normal with them once they have been on the truck a while, a bit of something always blocks them. Not much point in them in my opinion.
If having problems with water in fuel fit a proper sediment filter. Single Fuel Filter Sediment Bowl Assembly Water Separator 1/2" UNF 5836B120 | eBay A clear section of line where fuel line reaches engine bay will find if any air is getting in at the tank/pump end [ electric pump?] of the system.
Click to expand...

I have a sedimenter on mine and it’s astonishing the crud that accumulates in it over a couple of years
 
tottot said:
If not already done so change the fuel filter, often the source of the problem.
Click to expand...
That was indeed the issue! the old Male KC80 filter wouldn't drain or vent, guess it was blocked, new filter does both profusely. Possibly the noise from the pump was the second stage (HP) cavitating as it was starved of LP feed and gassing up. Anyway it seems to be running fine now. I fitted a new duckbill too as the old one couldn't shut its beak properly.
Thanks for your input everyone :)
 
You must log in or register to reply here.

Similar threads

W
Bleeding fuel system after pump repair
Replies
5
Views
855
lynall
L
A
Defender 90 air constantly through air bleed.
Replies
2
Views
659
antccp8
A
Seaswood
2.5 na smoking
Replies
14
Views
529
Seaswood
Seaswood
T
200tdi oil coming out of air filter box. Help!!
2
Replies
30
Views
3K
Dippypud
Dippypud
J
engine cuts out at high revs, eml on td5
Replies
2
Views
432
Tim4x4
Tim4x4
Back
Top