I need a sunroof sealant .

This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
OldIrishWulf

OldIrishWulf

Well-Known Member
Posts
3,974
Location
Great green Hibernia .
My sunroof is leaking . I'm sure the drain pipes are blocked , but I want to seal the gap between the rubber and the painted metal roof .
Is there a more suitable sealer than silicone ?
I could whip out the roof lining , then the sunroof and blow out the drain pipe but the sunroof dunt work and is beyond repair .
 
^^^^ Thats very good, same stuff i used to use but diff number...stick the tube in hot water before you use it
 
Sikaflex, can stick like sh*t to a blanket, used it once on rocker gasket on a Capri. It took 6hrs to get cover off next service. Good Luck.
 
Slightly off-topic, but how do you disable the switch for the sunroof, once it's sealed. Both my sun-roofs were leaking and the guy I bought the car from, said he will permanently seal it, but it won't stop the kids from pressing the buttons.

Is there possibly a fuse I can take out, (that will only disable the sunroofs),
or do I remove the switch and pull the wires out from behind it?

Any help would be appreciated.

Regards,
 
I used ordinary clear bathroom silicon sealant when I resealed the sunroof on my wife's car, works fine, no more leaks.
 
try removing the glass, and cleaning the seals with washing up liquid and water, then lubing the rubbers with vasaline or similar, grit n stuff gets into every little nook, and stops it sealing properly, its worth a try.
 
rlohiya said:
Is there possibly a fuse I can take out, (that will only disable the sunroofs),
or do I remove the switch and pull the wires out from behind it?

Any help would be appreciated.

Regards,
Click to expand...

On the freelander sunroof you can disconnect the wiring connector to the motor,it can be got at by removing the light in the roof lining .
 
I washed the car today and cleaned the green slimey muck and stuff off all the window and sunroof seals . Then I decided to cover the vehicle with a tarp ,its well tied down .

I also decided when my insurance expired two weeks ago ,to park it for a month or 2 . Tax will cost €200 for 3 months . I'm now insured on Ms.Fox's fiesta until October for the princely sum of 36yoyo .

I'm sort of tempted to go with the vaseline idea,but use Super Lube instead . I would prefer to be able to clean off whatever sealant I might use , just in case I ever pick up a good replacement sunroof cassete .
 
THEengineer said:
the big problem with silicone sealant is that it does not like sticking to rubber and shrinks with heat so on a sunroof where the sun heats it up it fails
Click to expand...

That's what I was thinking and there's no getting it off the paintwork . The tarp will do for now , and ,if the weather dries up a bit I will whip out the roof lining and sunroof , just to have a good look before I commit to anything permanent .
 
I finally got round to buying that tiger seal from the motor factors and whacked it on a few days ago .It was a bit messy,not as neat a finish as i woukd have liked. The tarp seems to have scuffed off patches of paint , it weren't such a good idea to leave it on for a week or 2 .

I'm going to leave it off the road for a few more weeks then tax and insure it
 
OldIrishWulf said:
I finally got round to buying that tiger seal from the motor factors and whacked it on a few days ago .It was a bit messy,not as neat a finish as i woukd have liked. The tarp seems to have scuffed off patches of paint , it weren't such a good idea to leave it on for a week or 2 .

I'm going to leave it off the road for a few more weeks then tax and insure it
Click to expand...

Tiger Seal is the gear to use. I removed my sunroofs, cleaned off the ****ty seal that was there, bead of Tiger Seal and been water tight ever since. Hope I never need to remove them again though, as that stuff is seriously hard to remove.
 
Sikaflex or tiger seal, both will do the job, neither will budge once dry, both will stick to the hairs on your arms and never give up...
 
You must log in or register to reply here.

Similar threads

SkeetRover
Disco 2 Sunroof opening misshapen??
Replies
3
Views
763
SkeetRover
SkeetRover
Kerlaan
Freelander 1 Facelift sunroof drain tube exit location [solved]
Replies
1
Views
1K
Kerlaan
Kerlaan
A
Freelander 1 Sunroof drain holes
Replies
5
Views
1K
Almiscarado
A
Montyjohn
P38A A couple of queries about rebuild EAS valve block
Replies
9
Views
685
Grrrrrr
Grrrrrr
MollyNomad
Freelander 1 Sunroof Mechanisms and Repair Guide to replacing Glass and Mechanisms
Replies
0
Views
1K
MollyNomad
MollyNomad
Back
Top