Hi I have noticed whist on idle and while running some flames come out of the exhaust. Has anyone encountered this and what could it be? Defender is remapped with a straight pipe. Thanks
Flames out of exhaust
- Thread starter incor98
- Start date
This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
myfirstl322
Well-Known Member
- Posts
- 41,354
- Location
- Hoots mon...
Cool as...
- Posts
- 22,902
- Location
- In the next Glen
I didnt get that with my re-map I will call tomorrow & complain.
myfirstl322
Well-Known Member
- Posts
- 41,354
- Location
- Hoots mon...
A bit of tin foil where the zortst exits is the only advice one can give.
Peeps would give their left arm for this.
- Posts
- 22,902
- Location
- In the next Glen
Could be running rich or too much boost, too much fuel from a sticking injector which ive seen flames out the rear muff
FlyingPete
Well-Known Member
- Posts
- 1,305
- Location
- Coventry
Not a very good remap or a sticking injector if you have actual flames from the exhaust. Fuel should be burning in the cylinder not down the exhaust pipe. For it to be running that rich, with enough unburnt fuel that you have combustion at the tailpipe is not good. Petrols are different as they will run richer than lambda 1 at high load and typically hotter, so you have unburnt fuel which can ignite on contact with the atmosphere.
Rock Basher
Well-Known Member
- Posts
- 191
- Location
- On The Hill
Shoddy.
That most definitely needs sorting out
That most definitely needs sorting out
- Posts
- 4,549
What is "Shoddy" about it ?
Why, in your opinion, does it 'need sorting out' ?
What is actually wrong with it ?
Is it flames or is it sparks? There is a huge difference in terms of diagnosis, flames (similar to a petrol backfire) is a much bigger problem in a diesel than bits of spark. Spark could be as above, but it could also be the soot covered packing of a silencer beginning to fail.
Rock Basher
Well-Known Member
- Posts
- 191
- Location
- On The Hill
doriz
Well-Known Member
- Posts
- 17,312
Is it a Jimmy Deville special edition?
300bhp/ton
Well-Known Member
- Posts
- 5,009
- Location
- Near MK
So you have no answer then?
300bhp/ton
Well-Known Member
- Posts
- 5,009
- Location
- Near MK
Very much this.
I do not see how a remap could cause this directly. Not even sure flames from diesel are really all that possible. The photos look like a spark or hot ember. So something hot breaking down between the engine and exhaust pipe.
Rock Basher
Well-Known Member
- Posts
- 191
- Location
- On The Hill
Going on house dirty that tail pipe is I would say you are definitely running to rich.
But of course that does not account for the sparks directly.
Of course it could be as I've been running rich for so long the whole inside the exhaust system is coated with carbon and that is what you are seeing coming out of the exhaust.
I would defo investigate.
But of course that does not account for the sparks directly.
Of course it could be as I've been running rich for so long the whole inside the exhaust system is coated with carbon and that is what you are seeing coming out of the exhaust.
I would defo investigate.
Its sparks but only did it one time never done it again yet
Its a td5inside remap with boost box has been on it for 3 years never seen it doing it. Hasn't done it today either
If it hasn’t done it in three years I doubt it is the remap. I come back to the exhausts either being clogged with spot and blowing it out or the packing beginning to break down in the silencer.
Yess probably in fact I gave it a bit of welly and the only packing exhaust has is the rear parts, which is only stock otherwise it is a straight pipe. And also hasn't done it anymore
