Datatek
Well-Known Member
- Posts
- 44,887
- Location
- Near Poitiers SW France
Clutch plate rattling?
P38A AC suddenly lost pressure - Now re-gassed but got strange noises
- Thread starter pwood999
- Start date
This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
Clutch plate rattling?
- Posts
- 33,600
- Location
- North Shropshire
If you turn the clutch by hand a few turns can you hear it? Any play there?
- Posts
- 12,628
- Location
- Sud ouest France !
It could well be the bearing behind the clutch mechanism, mine went bad after it was soaked in water.... Errrr..... For four hours
it's held on by a circlip once the clutch is removed. Watch out for the shim if you remove it!!! Unfortunately I broke the circlip end of the bearing shaft on my compressor 
it's been loctited on for over a year now
it's held on by a circlip once the clutch is removed. Watch out for the shim if you remove it!!! Unfortunately I broke the circlip end of the bearing shaft on my compressor it's been loctited on for over a year nowon that theme... energise the clutch with a 9V battery, engine off...can you manually move the clutch at all (ie could the clutch be slipping) maybe just check the clutch gap with a feeler gauge, for good measure
- Posts
- 3,878
- Location
- Near Heathrow.
Yes they put PAG in. Will try the other suggestions soon. At moment it seems to have quietened down & AC cools nicely !!
P38 Monkey
Well-Known Member
- Posts
- 628
- Location
- Cambridge
Same here - leak at top right corner of condenser. New condenser, problem solved.
(That's top right when viewed from driver's seat, as per standard JLR procedure.)
- Posts
- 3,878
- Location
- Near Heathrow.
Found the AC Gas leak on my P38. Looks like clutch needs doing as well, so new compressor complete with clutch required.
- Posts
- 12,628
- Location
- Sud ouest France !
Result, some manufacturers demand the drier to be replaced as well for the guarantee. Worth asking
- Posts
- 3,878
- Location
- Near Heathrow.
Might do that as well, but not looking forward to bumper off.
Trip to Bedford EuroCarParts with tools required !! My son can get staff pricing, so I can fit them & get Gas recharge in one trip.
Trip to Bedford EuroCarParts with tools required !! My son can get staff pricing, so I can fit them & get Gas recharge in one trip.
I try to spray some wd40 or similar the day before trying to remove something... Good luck?
On a different AC note:
Will a pressure test adequately check a system? Mine was tested and refilled hence assume no leaks. However AC does not cool :-( Cold at compressor/pipe in engine bay, and compressor just cycles on/off every few minutes.
Is there a good idiots guide on the AC system to troubleshoot?
On a different AC note:
Will a pressure test adequately check a system? Mine was tested and refilled hence assume no leaks. However AC does not cool :-( Cold at compressor/pipe in engine bay, and compressor just cycles on/off every few minutes.
Is there a good idiots guide on the AC system to troubleshoot?
Last edited:
doriz
Well-Known Member
- Posts
- 17,312
Come on shirley that is the best worst advice offered this year, unless you were advocating an insurance job pmsl here
- Posts
- 19,297
- Location
- Buckinghamshire, UK. ('95 DT)
TXV?
