td5 running out of fuel

This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
S

scotty281976

Active Member
Posts
182
Location
STOKE-ON-TRENT
bit of a weird on this, ive owned the discovery 3 weeks and the previous owner warned me it ran out of fuel at 1/4 full.
I removed the pump and sender unit last week to investigate and checked the sender and it seems to work fine when moved by hand from empty to full,
So I cleaned the gauze on the bottom of the pump and refitted it,

fast forward tonight sure enough it ran out of fuel at a 1/4 of a tank, so I put 10 litres of diesel in switched on the ignition and stamped on the throttle pedal 5 times to bleed it, waited 3 mins try to start it and the battery went flat within 2 turns of cranking.

so out come the jump leads and repeat the bleed procedure and fires up more or less straight away with a bit of coughing and spluttering and then drove home.

by the looks of it the pump has been replaced before its date stamped 2009, im wondering if the pump has gone weak or its sucking from the wrong height, has anyone else had the same problem
 
I know its not the sender at fault because if I fill it up when showing 1/2 full it takes about 50 quid to brim it,
plus looking at pics of a d2 td5 in tank pump the float and arm looks the same as mine ie: not bent
 
Get the pump out again and take some measurements of the pick up point and the depth of the tank, relative to the pump mounting flange. If there is a discrepancy, then the wrong pump has probably been fitted.
 
I think the original poster is saying that there IS fuel in the tank when the car stops running. I'd be replacing with a genuine VDO unit and thoroughly inspecting all the other elements of the fuel system, filter block, filter, air bleed valve, FPR, cooler.
 
you can replace only the sender(YAD500040)... put a new one as even if your's works outside by hand it's sticking in the reservoir imo
 
Last edited:
ive just done the following, removed the pump of of the tank, I sucked the 10 litres out I put in last night after running out.
then I sucked the remainder out which was 20 litres so in other words it runs out of fuel with 20 litres still left and the gauge shows 1/4 of a tank remaining so that rules out the sender being inaccurate.
the pump when refitted physically bottoms out then you have push it about 2 inches on the spring loaded mechanism for the pump flange to meet the tank.

the pump and sender are genuine its marked VDO which were fitted from factory
 
scotty281976 said:
ive just done the following, removed the pump of of the tank, I sucked the 10 litres out I put in last night after running out.
then I sucked the remainder out which was 20 litres so in other words it runs out of fuel with 20 litres still left and the gauge shows 1/4 of a tank remaining so that rules out the sender being inaccurate.
the pump when refitted physically bottoms out then you have push it about 2 inches on the spring loaded mechanism for the pump flange to meet the tank.

the pump and sender are genuine its marked VDO which were fitted from factory
Click to expand...

Did you check the flange to pick-up point measurement on the pump, and compare it with the flange to tank bottom measurement?
 
yes I checked the height its fine, I think ive found the culprit. there is another filter fitted to the pump body itself the pump assembly has to be dismantled to get to it,
as you can see below its well bunged up with black crap.
 
Interesting thread that has given me the motivation to have a look at mine when the weather picks up.

Mine too "runs out" at just blow 1/4 full on the gauge. Thus far I am living with it, but now I know what to be looking for my spanner fingers have started to itch.
 
my defender use to run out at quarter of a tank as it had loads of water in it took me ages to work it out cleaned tank out put pure diesel back in it and was fine after that may not be your problems but easy enough to check as if water in the tank undo drain plug on diesel filter and see if loads of water comes out or a mix of diesel and water
 
The main cause of water in the tank is caused by not keeping the tank topped up with fuel. When unused returned fuel enters the tank it is warm, and in colder temperatures can cause condensation on the inside of the tank if the tank is not kept topped up to a reasonable level with fuel. A place I worked at put drivers on a written warning if the vehicle they had driven that day was not fully re-fuelled before they went home. If a vehicle was left till the next day, the condensation that had happened overnight was enough to cause waxing in the filter during the winter months, this caused downtime and lost profits for them. When I first started driving I was given a really good bit of advice from my father........ It was "IT COSTS JUST THE SAME TO KEEP A VEHICLE HALF FULL TO FULL" as it does "TO KEEP IT EMPTY TO HALF FULL"
 
You must log in or register to reply here.

Similar threads

mad85
Disco 2 TD5 Low Fuel pressure!!
2
Replies
22
Views
621
mad85
mad85
G
TD5 Noisy fuel pump
Replies
3
Views
295
Anaconda
A
mad85
Disco 2 best place for fuel pressure sender on td5
Replies
10
Views
870
MJI
MJI
StuRox
Disco 1 Problem with Fuel Gauge - 300 Tdi
Replies
4
Views
610
StuRox
StuRox
D
Disco 2 td5 fuel purging doesn't work?
Replies
10
Views
591
Kev12
Kev12
Back
Top