battenberg
Well-Known Member
- Posts
- 2,101
- Location
- Birmingham UK
On engine idle I get a loud buzzing coming from the ACE block...
Anyone know the fix?
Anyone know the fix?
TD5 Ace Block Buzzing
- Thread starter battenberg
- Start date
This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
sierrafery
Well-Known Member
- Posts
- 17,871
- Location
- Arad/Romania
The only buzzing noise can come from the solenoids... on idle the horizontal one from the rear face(pressure controll valve) is under voltage so as any solenoid which is under power might make a buzzing noise if it's old/loosen... unplug it to see if it stops ... it's coil can be replaced as spare Britcar (UK) Ltd > RVT100020 PRESSURE SHUT-OFF VALVE COIL ACE DIS2(G)
Vehicle not moving
When the engine is running and the vehicle is not moving, both DCV's are closed, locking fluid in each side of the actuator pistons. The hydraulic pump draws fluid from the reservoir and passes it at very low pressure to the valve block. Because both DCV's are closed, after the fluid passes through the high pressure filter, it is directed through the pressure control valve to the reservoir. The pressure control valve is open fully to allow the full flow to pass to the reservoir. The DCV's will remain closed until the ECU detects a need to operate.
These valves ar normally closed when they are not under voltage
Vehicle not moving
When the engine is running and the vehicle is not moving, both DCV's are closed, locking fluid in each side of the actuator pistons. The hydraulic pump draws fluid from the reservoir and passes it at very low pressure to the valve block. Because both DCV's are closed, after the fluid passes through the high pressure filter, it is directed through the pressure control valve to the reservoir. The pressure control valve is open fully to allow the full flow to pass to the reservoir. The DCV's will remain closed until the ECU detects a need to operate.
These valves ar normally closed when they are not under voltage
battenberg
Well-Known Member
- Posts
- 2,101
- Location
- Birmingham UK
Thanks for the consise reply Sierra... will investigate and let you know.
eightinavee
Well-Known Member
- Posts
- 3,956
- Location
- UK.
Or you could check to see if there are any lumps of grit jammed between the chassis and valve block.
- Posts
- 2,884
This is exactly what I had a few years ago. It was driving me mad, and turned out to just be a jammed stone!!
battenberg
Well-Known Member
- Posts
- 2,101
- Location
- Birmingham UK
Thanks, will have a good look in the light.
Rus Britannica
New Member
- Posts
- 3
I have a similar problem. A loud and sonorous low-pitched buzzing that sounds and feels as if its coming from the chassis, which gets slightly quieter as the engine warms up, but at speed rises in frequency to a high-pitched whirring noise. I originally thought it was the EGR but am now convinced its the ACE.
Similar threads
