M.O.T.

This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
K

kenbro

Member
Posts
14
Talking to a TD5 owner recently who’d just had his Landy MOTd.
It passed, but garage told him, IF he’d taken it in after the new test came in it would have failed.
He thought this was because smoke could be seen coming out the exhaust.
Is this correct what he’s saying, because if it is, my TD5 has no chance to pass it’s july test.
And, if they fail it for smoking, what can be done to stop this? If anything.
Regards, Ken.
 
kenbro said:
Talking to a TD5 owner recently who’d just had his Landy MOTd.
It passed, but garage told him, IF he’d taken it in after the new test came in it would have failed.
He thought this was because smoke could be seen coming out the exhaust.
Is this correct what he’s saying, because if it is, my TD5 has no chance to pass it’s july test.
And, if they fail it for smoking, what can be done to stop this? If anything.
Regards, Ken.
Click to expand...

I thought it was only vehicles with DPF which were not allowed to have visible smoke
 
discool said:
@


There’s a lot on the WWW to help your understanding on the new MOT regs, such as with vehicles equipped with DPFs its emissions and zero smoke at idle which also goes for those non equipped.
Click to expand...

Most of them smoked from new they can hardly expect people to modify their vehicles so they’re better than from new. I’ve only read about DPF-equipped vehicles needing to be visible smoke-free. The WWW is full of as much rubbish as it is useful information. It will probably say in the updated MOT guidance
 
Bit of a dummy here, but, would my 2005 TD5 have had a DPF fitted when new?
On the original front exhaust pipe (Which I still have) there is a bulge part way down where the pipe is a larger diameter for 6 or 8 inches in length. What would that be?
Regards,Ken.
 
kenbro said:
Bit of a dummy here, but, would my 2005 TD5 have had a DPF fitted when new?
On the original front exhaust pipe (Which I still have) there is a bulge part way down where the pipe is a larger diameter for 6 or 8 inches in length. What would that be?
Regards,Ken.
Click to expand...

You don’t know what a DPF is, how it works or even what it look like then. Since 2009, and the introduction of the Euro 5 emissions standard, DPFs have been fitted to all new cars with Diesel engines... so does that help, but then maybe not.
 
kenbro said:
Bit of a dummy here, but, would my 2005 TD5 have had a DPF fitted when new?
On the original front exhaust pipe (Which I still have) there is a bulge part way down where the pipe is a larger diameter for 6 or 8 inches in length. What would that be?
Regards,Ken.
Click to expand...
no it woudnt
 
kenbro said:
Bit of a dummy here, but, would my 2005 TD5 have had a DPF fitted when new?
On the original front exhaust pipe (Which I still have) there is a bulge part way down where the pipe is a larger diameter for 6 or 8 inches in length. What would that be?
Regards,Ken.
Click to expand...
It'll be a CAT
 
discool said:
You don’t know what a DPF is, how it works or even what it look like then. Since 2009, and the introduction of the Euro 5 emissions standard, DPFs have been fitted to all new cars with Diesel engines... so does that help, but then maybe not.
Click to expand...
discool,
You’ve put that so eloquently even a caveman could understand it, possibly, even I.
Regards,Ken.
 
kenbro said:
Is this correct what he’s saying, because if it is, my TD5 has no chance to pass it’s july test.
And, if they fail it for smoking, what can be done to stop this? If anything.
Regards, Ken.
Click to expand...
not only a poor exhaust systems can create smoke ..injector issues EGR issues engine breathing to many things to list.... the coulor of the smoke out the chimney is a good place to start
 
kenbro said:
a bulge part way down where the pipe is a larger diameter for 6 or 8 inches in length
Click to expand...
Those measurements look a bit small for a cat. A cat looks a lot like a small silencer. You might be looking at a flexible coupling? A defender dpf is an extension to the cat and located between the engine and the cat, and has a sensor & cable fitted at the top which I guess is wired into the engine management system. The whole thing is a big lump wedged between the engine and gear box and fitted close up to the drivers footwell and extends all the way up side of the engine.
 
  • Like
Reactions: 8ha
discool said:
You don’t know what a DPF is, how it works or even what it look like then. Since 2009, and the introduction of the Euro 5 emissions standard, DPFs have been fitted to all new cars with Diesel engines... so does that help, but then maybe not.
Click to expand...

You want to try going to bed a bit earlier you might not be so grumpy :p

discool said:
@
There’s a lot on the WWW to help your understanding on the new MOT regs, such as with vehicles equipped with DPFs its emissions and zero smoke at idle which also goes for those non equipped.
Click to expand...

I have checked the MOT regulations, and vehicles fitted with DPF cannot emit any visible smoke. For vehicles without DPF the smoke test with a diesel smoke meter is carried out.
 
kenbro said:
Looks like I have a CAT. then, if I need it.
Thank you, Sir.
Regards,Ken.
Click to expand...
Wimblowdriver said:
Those measurements look a bit small for a cat. A cat looks a lot like a small silencer. You might be looking at a flexible coupling? A defender dpf is an extension to the cat and located between the engine and the cat, and has a sensor & cable fitted at the top which I guess is wired into the engine management system. The whole thing is a big lump wedged between the engine and gear box and fitted close up to the drivers footwell and extends all the way up side of the engine.
Click to expand...
He may well be looking at the flexible coupling!
My 1996 Defender has a CAT though, which is not a lot more than a large bulge in the pipe. It has not sensors or cables fitted to it, so god know how it works or how long it lasts cos it can't decide when to regenerate itself.
This is what it looks like 300Tdi with CAT @kenbro both the flexible coupling and CAT are in this picture
 
This is what a cat with dpf looks like on the Pumas. Should be easy to spot if you have one of these fitted.
 

Attachments

  • Defender MY12 Workshop Manual (dragged).pdf
    56.8 KB · Views: 360
  • Defender MY12 Workshop Manual (dragged) 2.pdf
    48 KB · Views: 418
  • Defender MY12 Workshop Manual (dragged) 3.pdf
    81.1 KB · Views: 332
Al2O3 said:
He may well be looking at the flexible coupling!
My 1996 Defender has a CAT though, which is not a lot more than a large bulge in the pipe. It has not sensors or cables fitted to it, so god know how it works or how long it lasts cos it can't decide when to regenerate itself.
This is what it looks like 300Tdi with CAT @kenbro both the flexible coupling and CAT are in this picture
Click to expand...
Cats dont regen nor have wires
 
You must log in or register to reply here.

Similar threads

G
TD5 Head Gasket?
2
Replies
24
Views
3K
Stanleysteamer
Stanleysteamer
T
Tillys smokey TD5, can we fix it ?
Replies
9
Views
753
tilly2
T
G
TD5 Mysterious Coolant Leak?
Replies
3
Views
828
Shedload
S
J
engine cuts out at high revs, eml on td5
Replies
2
Views
354
Tim4x4
Tim4x4
200tdi Land Rover 90
Defender TD5 2003 idle problems!
Replies
5
Views
1K
Anaconda
A
Back
Top