neilly
Well-Known Member
- Posts
- 20,000
- Location
- Oxfordshireness
OK, Did you check the actual flow rate? liters per minute
Cheers
Cheers
Lost power suddenly, now will not even start TD5
- Thread starter northernbobber
- Start date
This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
northernbobber
Active Member
- Posts
- 165
- Location
- Finland
how much should it be in a minute?
northernbobber
Active Member
- Posts
- 165
- Location
- Finland
I tried to block it by finger to see if it blocks but it was spraying like crazy
neilly
Well-Known Member
- Posts
- 20,000
- Location
- Oxfordshireness
Pump rates are listed in the Rave workshop manual.
Do you have it?
Cheers
Do you have it?
Cheers
northernbobber
Active Member
- Posts
- 165
- Location
- Finland
yeah we have all the manuals at the garage, I only checked the preassure but didn't look for flow rate.
neilly
Well-Known Member
- Posts
- 20,000
- Location
- Oxfordshireness
Only reason I ask, on my Fathers D2 Td5 when he got it. felt sluggish. I changed fuel filter on it and it would not start. When I checked the flow rate it was the same flow as specced for the LP pump side at the FPR. fitted my fuel pump and the car started. Then checked the fuel flow rate and it was as specced for the HP fuel flow rate.
To my mind checking pressure and flow at the FPR inlet if OK to specs , removes that side of the system from the equation.
Cheers
northernbobber
Active Member
- Posts
- 165
- Location
- Finland
Thanks Neilly, I see. Today I replaced the injector o rings and washers, cleaned that area. No difference. When I finally got it to start same issue. Ran for a little while, rough idle, smoke, and the shut off as if run out of fuel. The fuel preassure seem good before and after regulator. No leak at regulator. When the car shuts off, the fuel pump is quiet too... I don't remember how it should be. Should it shut off at stall or continue to run or do I have an electrical issue where the fuel pump is shut off after initial pumping? Now at home I am thinking maybe I have an air intake blockage. That could produce the smoke and the stall right? Have to take off the inlet hose again to check to that... Can the regulator be damaged in a way that it could produce issues like this, it's not leaking or showing reduced preassure.
and see if there's a hiss.
