Leaking FPR cause no start?

This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
If the fuel pressure regulator is leaking, as you say "a fair bit" then there's a good chance that your fuel isn't being sent to the injectors at the correct pressure. Consequently the correct amount of fuel isn't getting squirted into the combustion chamber, if at all.
Get the FPR fixed and then see how things go. It is a bit of a faff to get at, but a fuel leak is never a good thing.
 
I have read somewhere that a leaking FPR can allow diesel to get past the bellhousing joint and affect the clutch. Is there an easy way to tell if it is leaking?
 
brian47 said:
If the fuel pressure regulator is leaking, as you say "a fair bit" then there's a good chance that your fuel isn't being sent to the injectors at the correct pressure. Consequently the correct amount of fuel isn't getting squirted into the combustion chamber, if at all.
Get the FPR fixed and then see how things go. It is a bit of a faff to get at, but a fuel leak is never a good thing.
Click to expand...
Thanks Brian, if that’s the case then I’ll order a new one and try it. Just wasnt sure whether to get a new Crabkshaft Position Sensor too.
 
brianconwy said:
I have read somewhere that a leaking FPR can allow diesel to get past the bellhousing joint and affect the clutch. Is there an easy way to tell if it is leaking?
Click to expand...
I can stick my hand underneath it and feel the fuel leaking, but if it’s a less obvious leak you can stuff a paper towel under it and run the engine for a few mins - that should tell you! It’s bolted to the lower left of the engine block on drivers side.. you have to reach under the manifold - bit of a tricky position!
 
I will have a look on Wednesday when we get home. There has been intermittent slipping of the clutch, but my wife hasn't noticed it. It is only when it won't move at all that she will.
 
Another problem caused by FPR leak is that the fuel can reach the starter then it mixes up things there and the starter is spinning but can disturb the crank signal... IMO the leak in the diaphragm would not stop the engine to start and idle cos it can start even on low pressure just it doesnt have power.
 
You must log in or register to reply here.

Similar threads

W
Fl2 sd4 non start
Replies
8
Views
424
Nodge68
Nodge68
G
None starting discovery td5
Replies
0
Views
556
gary dhenin
G
mad85
Disco 2 TD5 Low Fuel pressure!!
2
Replies
22
Views
621
mad85
mad85
E
Disco 2 Fuel Leak
Replies
1
Views
140
Landmark2
Landmark2
loonyspoony
Disco 1 300TDI No Start
2 3
Replies
41
Views
2K
loonyspoony
loonyspoony
Back
Top