Hot start issue.

masonsjeep · Jul 9, 2015

Hi guys. I've searched but not found an answer.

I have a 2001 4.6. Its developed an hot start issue. drives great no problems. turn it off then it wont restart until it has cooled down.

any ideas. ??

masonsjeep · Jul 9, 2015

Possibly ecu temp sensor, but where is it, pics would help.

Anyone. ??

biketeacherdave · Jul 10, 2015

A quick search on Google confirms engine coolant temp sensor check rave for location

biketeacherdave · Jul 10, 2015

Also the fuel pump

masonsjeep · Jul 10, 2015

Would fuel pump be the issue, as it runs ok from cold with no issues. ??

Grrrrrr · Jul 10, 2015

masonsjeep said:
Would fuel pump be the issue, as it runs ok from cold with no issues. ??

Possibly. If pump is worn and a bit loose then might be looser still when hot and not have as much pressure. Not sure how much difference that would make to a petrol though.

biketeacherdave · Jul 10, 2015

Well the fuel pump is coming up on the 4.6 petrol more often than anything else as a cause

Grrrrrr · Jul 10, 2015

biketeacherdave said:
Well the fuel pump is coming up on the 4.6 petrol more often than anything else as a cause

Can you test how much fuel it should eject? Guess you could compare hot and cold and see if any difference.

masonsjeep · Jul 10, 2015

I thought the fuel pump was at the rear ?

Grrrrrr · Jul 10, 2015

masonsjeep said:
I thought the fuel pump was at the rear?

In-tank pump certainly is but the fuel lines go all the way to the front.

PPP38vouge · Jul 11, 2015

The coolant sensor sits behind the air con compressor at the front of the valley gasket, but your problem sounds like the CPS, the one above the bottom pulley, normally hard to start when hot is a sign that the sensor is giving up the ghost.

masonsjeep · Jul 11, 2015

Ill try the crank sensor too. Thanks guys.

masonsjeep · Jul 11, 2015

After a bit more googleing . Crank position sensor seams to be at the rear of the engine near the gearbox. Is this the 1 I should be changing. ?? I can wield a spanner if I know what I should be taking off and replacing.

Datatek · Jul 11, 2015

masonsjeep said:
After a bit more googleing . Crank position sensor seams to be at the rear of the engine near the gearbox. Is this the 1 I should be changing. ?? I can wield a spanner if I know what I should be taking off and replacing.

Don't know exactly on the V8 but it will be at the back of the engine poking i to the flywheel. If it's like the diesel, don't remove the mount or you will be in a world of pain.
Personally, I would get a can of freezer and spray the sensor when to car is hot and won't start and see if it then starts. Or diagnostics.

masonsjeep · Jul 11, 2015

Nothing shows up on the diagnostics. Running out of options

Datatek · Jul 11, 2015

masonsjeep said:
Nothing shows up on the diagnostics. Running out of options

Even when it won't start? If it's the CPS, the lack of a signal should be plain to see on live data when cranking. Freezer will probably prove the point.

masonsjeep · Jul 11, 2015

All sorted.!!! Crankshaft Sensor.
Thanks for the help.
You guys are great.

ovalandrover · Jul 12, 2015

Just got off the ferry from iceland and had a couple of problem there likr the bolt holding the transfer case on sheared and it nearly fell off so got that sorted and did another 7000 miles and the sharp lava roads Fu### 2 tyres and they wanted 250 quid each so got a second hand one for 40 quid which got ub back to germany where I got 2 mtchekin lattitude cross for 370 euros for 2.
On the last day in nIceland the starter refused to turn over but after a bit of cursing and jiggling it started and got me to the ferry .but nearly refused to start when getting of the ferry so I replaced the starter motor in germany as well asnother 400 euros,
Got to poland today and went to Gadansk for the afternoon but when I started it there was a loud bang and rattle so stopped the engine and looked under the bonnet and the belt tensioner bracket had broken so now I got to find anoyher one here .
I am due to cross into Russia in 3 days time so wish me luck as so far not so much
Iceland was an awsome trip but the mountain roads were not open so didnt get to do all we wanted so looks like we will have to go back for the third time to do them

Hot start issue.

masonsjeep

Member

masonsjeep

Member

biketeacherdave

Well-Known Member

biketeacherdave

Well-Known Member

masonsjeep

Member

Grrrrrr

Technician, Bodgit & Scarper Ltd

biketeacherdave

Well-Known Member

Grrrrrr

Technician, Bodgit & Scarper Ltd

masonsjeep

Member

Grrrrrr

Technician, Bodgit & Scarper Ltd

PPP38vouge

Active Member

masonsjeep

Member

masonsjeep

Member

Datatek

Well-Known Member

masonsjeep

Member

Datatek

Well-Known Member

masonsjeep

Member

ovalandrover

Well-Known Member

Similar threads