Disco 2 Disco TD5 Auto - TC lockup

This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
tom1979

tom1979

Well-Known Member
Full Member
Posts
2,141
Location
East of England, UK
Morning all,
Can anyone explain when the TC should lock up? I had noticed it locked up at just over 50mph however recently I have noticed this doesn't happen until the engine has warmed up. Is this normal?

It may have always done it but I've been using it to go to work which is a short journey barely long enough to get the engine hot
 
Great. I was hoping it might be, just wanted to check the TC wasn't cooking itself! Is it based on engine temperature or is there a thermostat in the box?
 
That explains it then. I just had a quick look at RAVE and it just says the lock-up is dependant on throttle position, engine speed, operating mode and the range selected on the transfer box.
 
The temp sensor on the oil cooler is exclusively for high temp warning, the input goes only to the instrument pack it's not part of the management but the engine temperature is sent via CAN from the engine ECU to the autobox ECU and it's part of the overall autobox management strategy so IMO that's the relevant element in this
 
I sometimes think that the gearbox would overheat rather than drop lockup in 1 mph earlier.

To be honest it is not a great autobox, it is pretty average, and the control is a bit pants.

I have a lot of experience driving 4 speed electronically controlled GM gearboxes and to be honest they were a lot better, better control, better lockup usage, better shift quality, much better at reading what the driver actually wants. 4 speed longitudinal box, predecessor of the L322 box. Only thing the ZF box is better at is handling the torque.
 
The last auto I had was a Borg Warner 3 speed on a Maestro Vanden Plas in the mid 1980s and the Disco one is infinitely better. The shifts are almost imperceptible and it seems to do everything I want. Maybe I'm easily satisfied......
 
iansoady said:
The last auto I had was a Borg Warner 3 speed on a Maestro Vanden Plas in the mid 1980s and the Disco one is infinitely better. The shifts are almost imperceptible and it seems to do everything I want. Maybe I'm easily satisfied......
Click to expand...


The older 3 speed boxes with small engines are pretty terrible.

Jatco feel very fragile.

My worst driven is a 3 speed in a Cavalier, then a Ford Granada, then Jatco 5 speed, then ZF non electronic, ZF electronic, GM 4 speed 4L30 range, however the big LR too many gears ones seem fine, but not enough experience to rate them. But around 140,000 miles with the GM box
 
You must log in or register to reply here.

Similar threads

02Disco2
Disco 2 Abs & TC lights but no fault codes
Replies
1
Views
211
sierrafery
sierrafery
KiwiTDI
Disco 1 Torque converter lock up clutch “slipping” after lock up
Replies
7
Views
478
KiwiTDI
KiwiTDI
A
D2 autobox shudder issue (maybe)
Replies
8
Views
943
Stanleysteamer
Stanleysteamer
G
None starting discovery td5
Replies
0
Views
556
gary dhenin
G
Padda.116
300tdi auto disco 1 BURNING RUBBER SMELL
Replies
4
Views
380
patrickmoran
P
Back
Top