disco 200tdi engined power loss

nickliv · Oct 20, 2015

Climbed a big hill yesterday with the new chassis etc in the trailer. Pulled OK, turbo has always been whistly. Stopped at the top for a pee, left it ticking over, and all the way home it made no boost.
No smoke of any kind.
Ideas anyone?

300bhp/ton · Oct 20, 2015

Do you have a boost gauge?

Worth checking all the hoses tbh.

nickliv · Oct 20, 2015

I should add, its in a defender, and is running on the last 50/ 50 SVO /DERV mix of the year. Fuel filter is under a yr old, oil and filter 1500 miles ago. There is no roughness at the upper rev range, and there isn't any black smoke etc. The actuator rod has not been tampered with, and the pump isn't turned up.
I have a gauge fitted and whereas it used to go up to 12 -14 psi, its now showing about 1.

300bhp/ton · Oct 20, 2015

In that case it's obviously a boost/turbo thing.

Is the actuator jammed? Is the turbo spinning? Is it leaking boost after the turbo?

nickliv · Oct 20, 2015

I haven't touched the actuator properly yet. Does it need a lot of force to shift it? Perhaps I'm not being brutal enough.

nickliv · Oct 20, 2015

Hoses all seem ok too.

zeaphod · Oct 20, 2015

Don't think it should require masses of force. Although it's a different sort of TDi, have a look here: http://www.myturbodiesel.com/wiki/v...ustment-repair-replacement-on-tdi-engine-mk4/

tottot · Oct 20, 2015

Change fuel filter,then check lift pump.You wont get any boost if motor is not getting enough fuel.

lynall · Oct 20, 2015

Check the little black signal signal pipe from the turbo to the top rear of the injector pump, pipes falls off = no boost = no extra fuel, had it happen to me once oh dear!

disco 200tdi engined power loss

nickliv

Active Member

300bhp/ton

Well-Known Member

nickliv

Active Member

300bhp/ton

Well-Known Member

nickliv

Active Member

nickliv

Active Member

zeaphod

Well-Known Member

tottot

Well-Known Member

lynall

Well-Known Member

Similar threads