2nd gear hard to engage FL 2 Manual

Andcaff · Nov 2, 2015

Hi
Had vehicle just over 3 months now and i have only one issue with it thats slowly getting on my nerves. When moving from 1st to 2nd i have to virtually force gear stick to engage especially moving off and especially when entering roundabouts where concentration should be fully on road.no issue going down the gears.i have tried various techniques low revs,hard pressing clutch also not doing my kneecap any good.
Has anyone any had this issue and resolved it.
Thanks in advance
Andcaff

td4van · Nov 3, 2015

Check the reverse gear lock out pin

You may need a new gear change turret to resolve

Andcaff · Nov 4, 2015

td4van said:
Check the reverse gear lock out pin

You may need a new gear change turret to resolve

Is that an expensive job ?

td4van · Nov 4, 2015

Not sure I'll have a quick look into it for you

td4van · Nov 5, 2015

New gear change turret is around £75+VAT (LR034102) and labour is around an hour.

The other thing to check before replacing this part is the ball joints on the selector cables and gearbox - the cables should move freely on the balls and the balls should be tight (20Nm)

Maybe a spot of grease could help solve it and it's cheaper

Grayo · Nov 5, 2015

I had the same problem with mine. I used white spray grease on all the linkage points, this made a big improvement but didn't last all that long but what I did then was to change the gearbox oil and wow what a difference smooth gear change up and down, I did this over two years now and it's still as smooth now as it was then. My car was on 60k at the time so did all the oils at the same time.

Andcaff · Nov 6, 2015

Thanks guys

2nd gear hard to engage FL 2 Manual

Andcaff

Member

td4van

Well-Known Member

Andcaff

Member

td4van

Well-Known Member

td4van

Well-Known Member

Grayo

Active Member

Andcaff

Member

Similar threads