TD5 on off power loss on acceleration

This site contains affiliate links for which LandyZone may be compensated if you make a purchase.
MJI

MJI

Well-Known Member
Posts
15,982
Location
Worcester
Happened again, new loom, cleaned sensors.

OK then no power, 1 second later power 1 second later now power, did this 3 or 4 times until I worked out it would not stop doing it.

less revs OK

Was OK later.

Very odd.
 
Still messing with full tank, but also varies what it does. Will finish a few other jobs first.
 
Still playing up wastegate modulator is on list to replace.

But had the issue today below 4000rpm for the first time.

All intake sensors cleaned, wastegate arm is free. New fuel filter.
 
MJI said:
Still playing up wastegate modulator is on list to replace.

But had the issue today below 4000rpm for the first time.

All intake sensors cleaned, wastegate arm is free. New fuel filter.
Click to expand...

I have a brand new modulator for sale £15 +postage if your interested:)
 
OK here goes, wastegate appears to be not sticking, new boost modulator, half tank.

Still does it a bit, but then I thrashed it up and down the bypass and it played up 4 or 5 times over 4000rpm then after a couple of runs started to behave.

Very odd.
 
Just did my modulator and found that 2 of the 3 vacuum pipes that go to it were split/holed.

Replaced pipes, but bore of new pies are bit bigger than original, so still a bit of a problem there. Will source correct bore pipe and presume problem will entirely disappear then, as it did for about 20 minutes when I bodged the original pipes with tape to get me to the shops.
 
Maaarrghk said:
Just did my modulator and found that 2 of the 3 vacuum pipes that go to it were split/holed.

Replaced pipes, but bore of new pies are bit bigger than original, so still a bit of a problem there. Will source correct bore pipe and presume problem will entirely disappear then, as it did for about 20 minutes when I bodged the original pipes with tape to get me to the shops.
Click to expand...

thanks I will check pipes
 
OK found the issue

Grossly overfueling at full RPM

Cost me £225 to fix, slightly quicker full throttle and better on part throttle

MUCH smoother

Thanks Mike
 
You must log in or register to reply here.

Similar threads

Keith_L
Disco 2 3 Amigos - sort of
Replies
3
Views
415
Keith_L
Keith_L
G
Disco 2 TD5 white smoke at idle
Replies
18
Views
684
GaryWrench
G
B
Heavy black smoke and very poor fuel economy
Replies
19
Views
2K
MJI
MJI
Airgunner
Td5 15p headache
Replies
9
Views
805
jamesDiscoTD5
jamesDiscoTD5
bahteles
Disco 2 Td5 No power after 2.5k - 3k RPM
2
Replies
27
Views
3K
bahteles
bahteles
Back
Top