Sunroof leak - crack in the frame.

Dexter · Aug 1, 2008

Hi there

Am the Mummy to a wonderful '03 TD5 who is leaking. have had roof inspected and crain tubes clear but they found a crack in the near side top corner of the sunroof frame. Only way to sure is to replace whole sunroof.

Just wondered if this was a known feature of the Disco? Help very gratefully received

Thanks
Dexter's Mum

nags100 · Aug 1, 2008

hi dexter not sure about crack as probably seal with silikon but most problems with disco2 sunroofs leaking is the seal between frame and body.
you can now get the seal from main agent at about £10 not to bad to fit major job is getting headlining down
hope this helps
gaz

andymach23 · Aug 2, 2008

Dexter said:
Hi there

Am the Mummy to a wonderful '03 TD5 who is leaking. have had roof inspected and crain tubes clear but they found a crack in the near side top corner of the sunroof frame. Only way to sure is to replace whole sunroof.

Just wondered if this was a known feature of the Disco? Help very gratefully received

Thanks
Dexter's Mum

Hi there,

My sunroof leaks on my TD5. As an experiment I put black insulating tape around the sunroof where the frame meets the roof. I just wanted to see if thats where the issue was, before dropping the headlining to fix the plastic plugs where the drains leave the tray. This is another main problem area.

The insulating tape fixed the problem and cost me 80p. I'll likely get a small tube of black silicone sealant and run it round the frame for a permanent repair.

You could try this approach as well and just silicone the crack. If it's done neatly it would be a fine repair and save you a small fortune.

Cheers

Andy

discool · Aug 2, 2008

Hi Dexter, this link on sunroofs by Manta Mad may be of interest 2U Discovery Sunroof Guide

Dexter · Aug 3, 2008

Thank you very much. I thought of tape/silicone but not sure if it will compromise the drain tubes .... will try the duck tape I have for the kids on the roof and see how we go. It does depend which way the car is parked too, but thats obvious I guess.

Oh and I don't really tape the kids up just in case you were worried ....

The Mad Hat Man · Aug 3, 2008

int it Duct tape - or is your feavvery?

90boy · Aug 3, 2008

fix it your self it will be a lot cheaper

Dexter · Aug 3, 2008

Yeap it is duct tape sorry for being an ill informed woman!!!! I must go do the housework as pennance (is that spelt right?)

The Mad Hat Man · Aug 3, 2008

who cares - house and work are both an unknown to me

Dexter · Aug 4, 2008

Its raining here again today but an emdeavouring to get the DUCT tape on and see what happens ..... if it works then great if not I shall be after you lol

Sunroof leak - crack in the frame.

Dexter

New Member

nags100

New Member

andymach23

Active Member

discool

Well-Known Member

Dexter

New Member

The Mad Hat Man

Well-Known Member

90boy

Well-Known Member

Dexter

New Member

The Mad Hat Man

Well-Known Member

Dexter

New Member

Similar threads