I think you are missing the corner trim that is designed to cover that gap. Dont believe they are still available from LR, but Paul at Discovery2parts (01206 211623, back at work on 19th October) usually has some, also a guy on d2boysclub is I hope going to make some using a 3dprinter. It is...

BTW Paul is away until 19th October, if you need to contact him.

VERY unlikely the block is warped, heads do get warped and need skimming, although LR say this is forbidden, as the surface of the head, although aluminum has been "hardened" somehow. Rather than skimmed, I suggest it should be "resurfaced" to remove any twist, but ONLY if it is warped. If not...

+1, replace the tensioner anyway, they fail at about 120k miles generally, and although you can replace the bearing, the spring must be weakened by then. I would also ensure you have an original Contitech belt, many others do not have the ridges on the reverse to help them grip and therefore...

Many just fit a long bolt with a nut, rather then replace the entire housing, which may have the same problem, which is common as a result of overtightening.

Give Heathy a call at Discovery2parts, based in Essex. He'll have a good used working compressor to ship to you. Paul on 01206 211623 - office 07828 278465 07760 955966 07840 428888

Give Heathy (Paul) a call at Discovery2parts, based in Essex, but ships everywhere. He'll no doubt be able to provide a good used head or engine. He's a really good guy. Paul on 01206 211623 - office 07828 278465 07760 955966 07840 428888

+1 to what Landmark said. Usually the leak is from the actual regulator itself, but its almost impossible to change without removing the regulator housing, so you will need a gasket. Make sure you only replace the regulator with a genuine Bosch one, or it will leak again in no time. If youre...

Anybody before it goes on the bay..?

Hi and welcome.........................

I have for sale a NEW unused TRW PSA510 brake servo, for Defenders, supplied in error. As below Same as here: https://www.autodoc.co.uk/trw/2211030?gadw=1&gclid=CjwKCAjwq_D7BRADEiwAVMDdHlbzjwAepR3AcToGIxZgoTHVbPgs67Iujc6Mljxb1pAWtVIEeW31uhoC3GEQAvD_BwE and elsewhere cheaper (£135 on the...

Rather than change to coils get some emergency inflation valves from fleabay here https://www.ebay.co.uk/itm/DISCOVERY-2-AIR-SUSPENSION-PUMP-AIR-SPRING-MANUAL-INFLATION-BYPASS-4MM-OD-VALVES/282534767304 and until you can resolve the issue just connect them into the airlines to the bags and...

Does it have ACE? If so remove R14 relay, and see if it still does it. If it does its suspension. Removal of R14 stops the ACE working, and puts it into locked bars mode, in case it is this. If it stops check the connections to /or the accelerators themselves. Tony

As said, you need to get the codes read with a Nanocom really. Could be a fuel pump issue as suggested, or CPS, (Crank Position Sensor). There are not many things that actually make a TD5 stop. Tony

No, they shouldn't, just disconnect battery first, jack it up on the tow bar, and change bags and sensors

See here for answer and technical bulletin that applies to this. https://www.landyzone.co.uk/land-rover/handbrake-drum-rattle.328134/#post-4222102 Tony

I'm not sure there is enough room to get at it properly, but if you can all well and good. Sorry to say it may be a drop tank job, but that is not too difficult a job, just put loads of release fluid on the nuts for some days before attempting to undo them. Tony

1, there is no sedimenter on a TD5, only the fuel filter, which is on the drivers side. If the leak is on the passenger side, the best advice is a good clean and then see where it appears from. There is nothing on a TD5 on the passenger side of the tank, so it is travelling maybe from the...

+1 the filler cap MUST be with the raised section along the length of the vehicle, or nearly, otherwise it wont close. Tony

The Powerline one certainly does not have them in the middle, as that is what I bought, see attached link https://www.tayna.co.uk/car-batteries/powerline/?ordering=&A-26=930 Some do, some don't, but it may cause you problems with the earth lead if it has. Tony