Ian Mackay

Ian Mackay

Active Member
Ok just a wee quickie, been fitting a reconditioned fuel pressure unit, disturbed the cooler and its leaking, taken both pipes off just need to know does the flow go from front or rear, is relevant, as may have a tiny piece of sealer in one pipe connection at fuel pressure unit, if its going back to filter fine, if its heading for FPU, will need to remove unit and clean, AGAIN, thanks
 
Hi @Ian Mackay

Just in case you ain't worked it out yet.

upload_2017-11-12_11-24-9.png


Cheers
 
Don't drive it much without fuel cooler or if it's bypassed dont let the tank below half cos you'll end up buying a pump too
 
sierrafery said:
Don't drive it much without fuel cooler or if it's bypassed dont let the tank below half cos you'll end up buying a pump too
Click to expand...
Cheers mate bear that in mind, just waiting for replacement to arrive tomorrow, don't know why it's called a COOLER, as it appears that its their to WARM the diesel to help with atomisation 82° being the set temp, it's only been 1°/2° here the past few days so it's much needed.
 
firtly it warms the fuel up untill 82° then the thermostat opens and starts cooling it, the fuel temp should be always around 10°-15° lower than the coolant temp cos it takes the coolant from the bottom of the radiator especially to not let 92(or above)° fuel getting into the tank/pump
 
You must log in or register to reply here.

Similar threads

stumpyj
Fuel Line worn through
Replies
2
Views
586
stumpyj
stumpyj
stumpyj
(2000 TD5 90 defender)TD5 Fuel Pump
Replies
4
Views
362
stumpyj
stumpyj
S
2012 Disco 4 Just wont start.
2
Replies
28
Views
5K
Graculus
Graculus
Goc3k
Discovery 1 SOLD 1997 300TDI manual D1, Winchester
Replies
16
Views
4K
Goc3k
Goc3k
MollyNomad
Freelander 1 ‘The Lambada’..(Three steps forwards..Two steps back/Rinse and repeat..) AKA Brakes Bled!!
Replies
0
Views
791
MollyNomad
MollyNomad