M

mark.peters

New Member
Help ....

My 1998 2.0ltr Diesel Freelander is not very well ...

Starting from cold is troublesome ... engine cranks for anything upto 15 seconds before firing ... yet when hot no problem at all. Engine cranks well, and attempts to fire but soemthing is holding it back almost ...

Personally I suspect Fuel Filter .... and not the glo-plugs .... what do you guys think ?

My suspicion is based on Landrovers own Technical Bulletin (number 0016 dated 13/03/99) which states that poor performance / starting issues are usally linked to diesel fuel filter.

Anybody else suffer from this ?

Cheers

Mark
 
Welcome mark!
id agree with yer if it wernt for it startin ok when hot
have you tried givin the glow plugs two of three attempts before crankin it over ?
 
Yep - have tried giving the glo-plugs a couple of turns - but seems to make little or no (noticeable) difference.

I've read stories about low fuel pump pressure, fuel pump problems etc but I haven't got any of the other symptoms.

Oh yeah - in the summer months everything is fine ... no starting problems at all. Is there some kind of temperature sensor that affects / controls starting perhaps ?

Cheers

Mark
 
Yup!

get yerself a new filter on then and see if it cures it.

at 250 squid yer dunt want to be chopin the in tank fuel pump unless you need too!
 
DOn't overlook the glow plug relay. This can suffer from burnt out contacts and corroded connections. Its worth replcing for the low cost involved.

Ron
 
Mark,
I sympathise mate, I've got exactly the same problem.Loads of white smoke when she finally fires up?....I've so far changed the fuel filter, fuel pump( replaced wiv one out a rover 420d-exactly the same, 1/3rd the price..), all glow plugs and the relay as listed by RoverRon. My current thought is an air bleed into the fuel lines, if it ain't that I fink me compression's up the swanny, and not sure how I'll deal with that.:confused:


A gallon of 4 star and a box of matches probably....:p
 
morning Cashew - just seen ya Avatar - cant make it out proper like - but is that Yella morphing into some kinda bird?
 
Naa Hatters, just a Welsh Doggie entertaining itself...Got bored wiv it tho, see me new one....
 

Attachments

  • chienfou.jpg
    chienfou.jpg
    83.9 KB · Views: 200
  • 7110_1.jpg
    7110_1.jpg
    22.8 KB · Views: 225
Thats a hell of a way to park it in ya garage!:D
have yu seen wot its done to the tool box .
The guy in the back dont look too pleased - and is that a teddy in the front?
 

Attachments

  • untitled.jpg
    untitled.jpg
    21.3 KB · Views: 230
Try swapping the starter and adjacent relays over, they’re both the same rating. Should identify if the relay was faulty. They live just behind the battery.
If it helps, renew the starter relay with an up rated 70amp version, cheapest I could find was £6, from 12 Volt Relay - heavy duty make and break
If not, check the earth strap from engine to body. Take it off, clean it and the securing bolts or nuts up and re-fit. I had a problem on an old motorbike because the earth strap securing bolt had been fixed with a threadlocking compound that also partially insulated the strap. If you have a spare bit of strapping, might be worth having two installed?

Someone on this forum also mentioned a gauze filter on the lift pump that may require cleaning, but the relay and earth strap fix sorted mine out before I had to go looking for it.

Good luck!
 
I read somewhere that its the pump timing can be out due to it being set with slack on the lower belt run. Mine is a pig when cold. It has all of the symptoms you have talked about. I will get round to setting the timing. but once it starts, you forget. I'm now used to giving it a squirt of easy start every morning.
 
Well - just an update :)

My Freelander went in for an service & MOT. Anyway - she passed the MOT fine - no problems at all.

I mentioned the starting problem, and all the usual checks were carried out (Glo plugs etc) - all were fine. Then the mechanic (not a Land Rover one I hasten to add) noticed that the 4 pipes leading off from the fuel pump were quite badly corroded -- so he replaced them all (just over £5 each - quite reasonable I thought) and since then (admittedly only 2 cold morning starts) have all been fine - starting almost instantly / within a couple of seconds ... much more like a diesel should ...

I'm hoping that's cured it ... but so far so good !

Thanks for all the replies guys !

Cheers

Mark
 
Latest update campers!

Me rad blew last week...those nice chappies at Nene Overland managed to replace it in 48hrs for £270 fitted. They also foc looked at the fuel pipes from the rear pump and found no corrosion. Ah well, one less area to check..they also cleaned the egf/maf, not sure which, couldn't speak to the mech who actually did it, but it made a, say 10% improvement in the start, still ****e but....

I'm now left wiv checking the pipes leading to the injectors I reckon, unless anyones got other suggestions.....:eek:
 
You must log in or register to reply here.

Similar threads

Maat
Disco 1 300tdi diesel leak
Replies
11
Views
347
Maat
Maat
D
Non-starting 1997 Freelander L-series
Replies
5
Views
448
Freddie17
Freddie17
S
Series 3 Diesel fuel bleed / starting issue
Replies
7
Views
2K
sjr202
S
D
Freelander 1 OBD reader for a 1997 Freelander L-series 2.0 litre diesel
Replies
8
Views
1K
doctortom2001
D
R
Freelander TD4 starting problems
Replies
8
Views
1K
Nodge68
Nodge68