P

pishmishy

New Member
I'm looking to run my 200tdi defender on biodiesel (not SVO :)). As far as I understand, this should be fairly straight forward, I just need to watch the fuel filter after the first few hundred miles and I may need to change some hoses.

How can I tell if the hoses fitted aren't suitable and need to be replaced?
 
seanmoore2006 said:
looks to be just poor quality fuels that might do it
Click to expand...
Neither source reads like that to me :confused: As far as I can tell biodiesel does slowly dissolve natural rubber. From the sound of it - it's not an issue someone's had with land rovers. :eek:

What else I've read seems to indicate that it's a problem that'll occur slowly if at all so there'll be time to catch it as long as it's being watched for.
 
1. Biodiesel is a great solvent. this means that it attacks rubber hoses and seals. This is not a problem with post-about-1994 vehicles as they have biodiesel-compatible materials. With older vehicles we have seen flexible fuel lines and return lines slowly swell and lose their grip. Luckily replacement of these hoses is an easy job. Seals inside the fuel pump would be harder to replace but we have not heard evidence of problems with these. The solvent quality of biodiesel also means that it will dissolve any gunk in your fuel tanks and more than likely deposit it in your fuel filter. The solution: change fuel filter within 1000 miles of switching to biodiesel (or when problems such as sluggish performance manifest themselves). Almost all the reported problems we have come across with biodiesel have either been due to very poor quality fuel (not from us!) or due to a blocked fuel filter.
 
Natural rubber hoses maybe, but they're affected by mineral diesel too and haven't been used by most car manufacturers for fuel lines for flippin' ages.

Where, other than the fuel tank, were you planning on putting the BioD ? If you're not planning on using it for windscreen wash or coolant - then the only possibility for hoses that would need replacing would be fuel tank to lift pump , lift pump to fuel filter and injection pump return to fuel filter.

I've just been out to look at mine and, while I suppose it's impossible to be absolutely sure without testing a bit of each pipe, mine certainly look like a polyurethane rather than rubber - way too thin walled to be rubber.

Hope that helps,
 
Yep Thats correct

If you got a older vehicle older than about 10yrs watch your fuel lines as it seems that bio doesnt like older rubber composites on the 300tdi to make sure i ran a new run of top quality fuel line from the tank to the main filter ont to the pump & PS dont forget your return hose if in doubt replace them ( you can good quality hose by the mtr from any good motor factorers)

With regard to the fuel filter - Bio (depending on the mix) tends to be a little more acidic than derv and so will have a flushing effect on your tank thus flushing anything down the lines towards you main filter.

I run my 300tdi & 2001 Range Rover p38 on Bio /( German DIN spec which is a 10% - 15% mix) runs fine in both cases.
The RR i Run a tank of bio on my weekly trip and then a tank of good quality Derv - each week i do about 750-800 miles mainly motorway
When i did change over i started fueling it with Bio for about 200 miles befoe it needed a main service and so the filter change was taken care of during the service
With the 300tdi /(the weekend vehicle) its on mostly always bio and no problems whats so ever - it was trialed yesterday & saw no drop in performance either off road or on! (ironically i have had more problems with crappy derv than decent bio)
When i changed over to bio on this i placed a in line filter just out side the main tank (Please note i use a electric pump to push diesel to the main filter and have by-passed the engine mounted mechanical pump)

As the in-line filter became blocked i justed pop it off when i became fouled.

hope the info helps

PS we run bio on out renault scenic "runnabout" too without problems
 
Sean,

1+1 != 3 mate.

What they're saying is:
1. BioD will dissolve rubber.
2. Most of their reported faults are not to do with rubber.

Most != All

Ergo, it's as easy to read into their statement that they have seen some faults with rubber components as it is that BioD doesn't affect rubber.

Yes BioD will affect rubber components... so will mineral diesel, just more slowly than BioD. Either way, replace them with something more inert ;)
 
Adz said:
I've just been out to look at mine and, while I suppose it's impossible to be absolutely sure without testing a bit of each pipe, mine certainly look like a polyurethane rather than rubber - way too thin walled to be rubber.

Hope that helps,
Click to expand...
Thanks, that's pretty much what I was expecting to hear. I'll check the hoses first anyhow, it's a '93 200tdi so it's just about old enough that I may have to be careful.
 
Adz said:
Sean,

1+1 != 3 mate.

What they're saying is:
1. BioD will dissolve rubber.
2. Most of their reported faults are not to do with rubber.

Most != All

Ergo, it's as easy to read into their statement that they have seen some faults with rubber components as it is that BioD doesn't affect rubber.

Yes BioD will affect rubber components... so will mineral diesel, just more slowly than BioD. Either way, replace them with something more inert ;)
Click to expand...

yer but but but ....... hmmm i sorta see where your coming from now i have re-read it
 
For God's Sake tip the stuff in the tank and get on with life, driving a faster smoother more economical car with less pollution than it ever had before!

Do not look for problems where none exist.

The 200 tdi is a PERFECT engine for biodiesel - none better.

I suggest in winter you stand by to cut it with some kerosene to help cold starting and keep the viscosity good, but other than that go for it.

If it was me, I would always have some DERV in the tank too, maybe a gallon in five or so. Our ACTUAL EXPERIENCE says this seems to help things along very nicely.

CharlesY
 
I want to run my 200TDI on Bio Diesel, does any one know of a company that can deliver it to my door in 25 liter containers to keep in my shed?
25ltr.png
 
A mate ran his 200 Disco on bio for years until the rust bug ate the truck. It sat for over five years untouched before someone wanted engine, battery on an it fired up in a couple of turns an ran just fine.
 
Everything I read seems to indicate the 200 TDi engine loves Bio diesel but my issue is where the hell do i get it?
 
Everything I read seems to indicate the 200 TDi engine loves Bio diesel but my issue is where the hell do i get it?
 
You must log in or register to reply here.

Similar threads

mjr92
Sluggish 200tdi
Replies
6
Views
638
mjr92
mjr92
I
Defender 90 200TDI Overheating - Replaced Everything
2
Replies
21
Views
2K
v8250
v8250
J
engine cuts out at high revs, eml on td5
Replies
2
Views
307
Tim4x4
Tim4x4
C
fair price for a 110 200TDi?
Replies
5
Views
585
captainmish
C
O
Defender running a disco 200tdi - fan shrouding
Replies
9
Views
1K
300bhp/ton
300bhp/ton