Tony e

Tony e

Well-Known Member
P38 dse alternator fault message came on and after about 10 mile and a couple of stop starts of engine in between the engine just died. Would not restart but had loads of battery power. Eventually started with a jump. Turned off and tried again without a jump, no joy. Would a duff alternator cause the engine to shut down or is there something else. Funny it starts from a jump. Any input would help. Thanks in advance
 
I guess without replenishing the battery the power just runs out. Diesels need a strong battery as the compression is very high. Check out your alternator output with a multimeter. The fact you can jump start suggests no other issues.
Jb
 
Put a volt meter across the battery terminals and see how much the voltage drops when starter engaged. then chech earth terminal.
 
Rangerover.net has a very good electrical troubleshooting guide. After that you could take the battery off, charge it and then see how it holds charge over the next few days. You can get the gubbins with the voltage regulator and brushes for about a tenner with the bonus that it has the higher set point of 14.5V for modern batteries.
 
Thanks for all the input. The battery had loads left when the engine cut out so why would it just cut out as a doosil dont need power to run. Or does it on a 38
 
Tony e said:
Thanks for all the input. The battery had loads left when the engine cut out so why would it just cut out as a doosil dont need power to run. Or does it on a 38
Click to expand...
The P38 needs LOADS of electrical oomph to keep the thing going....whilst a diesel in primative form requires nothing more than heat, compression, fuel and air to run, on a modern Diesel engine (the P38 included) requires electrical input to regulate the pump, read the sensors for optimal performance output, etc etc....if there is no power, the solenoid in the pump will close...or of the ECU isn't getting healthy power, it will shutdown, and turn off the engine.
 
Tony e said:
Thanks for all the input. The battery had loads left when the engine cut out so why would it just cut out as a doosil dont need power to run. Or does it on a 38
Click to expand...

If there was loads left in it and it was turning over then I think it might be an earth connection somewhere. Diag might help. ALTERNATOR FAULT is usually what it says it is. It is possible the diodes might have gone in which case charge might have gone back the wrong way. That would cause the message, might mess a sensor somewhere and for a while the battery would be OK. However, the battery might be receiving AC instead of DC or might be getting nothing.
 
Lift pump relay is pulled directly by + from alternator when engine is running. If alternator fails lift pump will die. If lift pump is genuine with NRV the injection pump may not be able to draw fuel past it at low RPMs. Hence the stall. ;)
 
Thanks again to one and all. Recon alternator fitted. Peace and harmony again:) wondered what was going on. All clear now. Thanks:):);)
 
Grrrrrr said:
Rangerover.net has a very good electrical troubleshooting guide. After that you could take the battery off, charge it and then see how it holds charge over the next few days. You can get the gubbins with the voltage regulator and brushes for about a tenner with the bonus that it has the higher set point of 14.5V for modern batteries.
Click to expand...
I replaced mine with item number 331890090841 off the bay,set point of 14.7, a tad over a tenner you cheapskate :p:D:D
 
Got the " alternator fault" message again, new alternator fitted, much smoother, and remarkable reduction in fuel consumption, would never have thought it would make that much difference ! Getting better than 10 l/100 heding on to 9.2:
 
You must log in or register to reply here.

Similar threads

JohnM70
L322 Turbo Actuator stuck?
Replies
9
Views
641
Blob
Blob
F
P38 DSE loss of power when driving
2
Replies
33
Views
2K
Mark Piercy
Mark Piercy
landyfun
300tdi alternator blocked up
Replies
1
Views
1K
v8250
v8250
C
P38 diesel not starting
3 4 5
Replies
97
Views
7K
Grrrrrr
Grrrrrr
RustyDefender
300tdi alternator
Replies
13
Views
769
RustyDefender
RustyDefender