Theres a bit of a story behind this one,so bear with me.
Last May whilst in the Pyrenees my 300tdi started running a bit hot,not off the scale,just touching the red area on the gauge.
So me thinks,thermostat is Fubared,so I took it out.All good,once warmed up gauge reads normal.
I have run it al the rest of this year with the thermostat minus the middle which I punched out.I read somewhere it's not good to run totaly without a stat.
Now the werather is much colder,I thiught I'd replace the Thermostat.So,motor warms up nice & quickly now,but not long after reaching normal operating temp it rises to just under the red.If I turn the lights or fan on the temp gauge goes right up into the red immediately.
So, I'm thinking something electrical,I have changed the temp sensor & stat.Do you think bad earth,& if so where would you suggest I start looking?
Thanks a lot guys.
Marc.

The gauge works by sending an earth from the sender unit in the head. I'd disconnect the plug there and test again with the lights/fan. If the gauge rises, you have a fault in the wiring back from the sender. If so, most likely behind the dash - look for wiring insulation damage where it passes over the many sharp metal bits.

zeaphod said:

The gauge works by sending an earth from the sender unit in the head. I'd disconnect the plug there and test again with the lights/fan. If the gauge rises, you have a fault in the wiring back from the sender. If so, most likely behind the dash - look for wiring insulation damage where it passes over the many sharp metal bits.

Click to expand...

I'd not thougt of that.
I'll try it later today.
Thanks
Marc

Check your earths

Just a quick update on this problem.
Turned out to be the earth strap from the battery to the chassis/transfer box.
Cleaned it up & re fitted,up to yet gauge has not gone above normal/vertical.
Thanks for the ideas & all your imput fellas.Much aprechiated.

Marc

Pleased to hear you got it sorted.
Remember that many problems are caused by poor earthing!