Evening gents, I wonder if anybody can shed some light on this for me. Disco 2 std air suspension, on a day to day basis if I open the tailgate there is no problem, if how ever I open the tailgate and leave it open( whilst load for tip trip etc) after 5 mins the rear suspension collapses, whilst...

Thanks for that, schoolboy error

Milton Keynes

Mark, the valve stems look to be sitting at the same height ,so hopefully the valve and piston are ok and I can not see any break in the spring either, still confused as to how the follower escaped. Most confusing is a lack of damage or marks on either follower of cam lobe. You are more than...

Ok,went to start the injector seal replacement and noticed that number exhaust valve had managed to spit out the rocker which was laying in the top of the head next to the injector.how the he'll did that come out ,is it possible to replace the rocker without removing the head?

Thanks I willcheck the fuel pump this afternoon and then tackle The injectors next weekend, thanks again for your help. I did check the pump for function and it sounded ok.

ok, slight emergency when I dropped the nanocom into the tray of diesel and old filter, but seems to be ok after a good drain and clean up !! all outputs look to be within the guide lines as detailed in the nanocom tech documents. starting to get frustrating. cheers for your help

injector seals is on my list of things to do, as I have noticed a 'slight' increase in the oil level over 1500 miles, so I have changed the oil as well

thanks, I am going to spend the morning with the nanocom, so I will report back later, I have already done the naocom test for the injectors and all 5 can be heard clicking ok, I also checked the throttle function, this is ok with the two values adding up to 5V as it should be.

gents, I have now replaced the MAF sensor airflow readings are now in the 60gr/hr on tick over so good news there, I have also fitted an EGR blanking kit to prevent any nonsense from that direction, still now power and running lumpy any ideas ??? adrian

can any body help?, D2 TD5 running rough with some but not much white smoke, the throttle response is poor in park or neutral but no power at all in drive, I have changed the fuel filter as this started after the wife ran around on the low fuel light, I have changed the injector harness and...

Okay thanks for that, as the injectors have been replaced in reverse order that would explain the lazy running.

gents, I think I know the answer to this but would like some confirmation, 6 months ago I had the head gasket replaced due to overheating issues, this sorted the overheating but the disco was never quite the same, a bit lethargic and lazy. Recently it has been running very lumpy so I plugged in...

the gods have obviously seen my post about buying a nanocom, just returned to the disco to find the three amigos laying in wait for me, the sun roof may be a gaffer tape repair for a week.!!!!

Disco2 TD 5 with 130k on the clock, already replaced the injector harness and drained the oil out of the ECU! it did cure the misfire though. Next job is to seal the sun roof. The Nanocom is on order!