seg

Member

• Aug 8, 2024

• #1

Hi all
My 300tdi has started to vibrate or shudder from about 50mph. Its noisier and seems to get worse going up hill.
The mechanic i took it too said my clutch was slipping and i had a new clutch fitted. Unfortunately its not cured it. Shudder and noisier at higher speeds.
In first to third gear its fine.
Apologies if this has been discussed before?
Thanks

 

1988smithy

Well-Known Member

• Aug 9, 2024

• #2

Have a gander at your running gear, particularly prop uj's and sliders. If somethings tired it wouldn't hurt to check halfshaft play and all other suspension bushings. Sticky brake calipers as well maybe.

For a bit of fun I'm gonna put 50p on.....rear prop uj at diff end

 

D1Nut

Well-Known Member

• Aug 10, 2024

• #3

Well I will go with one of the gbox mounts - 50 p in my currency is about 12 beers so too rich of a bet for me

although with clutch replaced you would think a bad mounting would have been seen - although same for the rear uj

 

tottot

Well-Known Member

• Aug 10, 2024

• #4

Back in May had similar issues, roughness mostly when accelerating and working harder like going up hill.
New mounts, engine and box sorted it.

 

miktdish

Guns n Chainsaws

Full Member

• Aug 10, 2024

• #5

D1Nut said:

Well I will go with one of the gbox mounts - 50 p in my currency is about 12 beers so too rich of a bet for me

Click to expand...

I wanna come to your country where I can get 12 beers for £0.50

 

tweedandbriar

Active Member

• Aug 10, 2024

• #6

miktdish said:

I wanna come to your country where I can get 12 beers for £0.50

Click to expand...

Count me in too!!!

 

norseman

Well-Known Member

• Aug 11, 2024

• #7

1988smithy said:

Have a gander at your running gear, particularly prop uj's and sliders. If somethings tired it wouldn't hurt to check halfshaft play and all other suspension bushings. Sticky brake calipers as well maybe.

For a bit of fun I'm gonna put 50p on.....rear prop uj at diff end

Click to expand...

Though you could reproduce a similar effect with a jubilee clip(s) though at today's prices that could work out more expensive

 

1988smithy

Well-Known Member

• Aug 11, 2024

• #8

norseman said:

Though you could reproduce a similar effect with a jubilee clip(s) though at today's prices that could work out more expensive

Click to expand...

I had a slight vibration over 50mph on me D2, the balance weight on the rear prop had half peeled away. Tapped it back and cable tied it sorted it

Recently been thru the intake and egr tract on me little van. Had to replace a few jubilees, it actually worked out cheaper to get t-bar clamps for the intercooler pipes!