E

Evan farmer

Active Member
just put the discovery 10p engine in my 99 defender had to change power steering pump to fit and few other bits but when I try and start it it just went one click fuel pump everything worked perfectly radio lights etc except it wouldn’t turn over found it to be the solenoid had disconnected itself put it back on it was turning over fine but no fuel pump agh none of the gauges worked either nor the radio but when I pull solenoid fuel pump works but radio and gauges don’t I connected live wire on the ignition barrel to the empty blade first time and it turned over on the first click could this have done anything?
 
ozzyboydeano said:
swap over a few relays I highly doubt that all relays to fail at once ..also check all earths and power connections
Click to expand...
It’s cranking over but it’s like it’s not getting fuel plenty of smoke and diesel leaking from the regulator and hissing noise from the regulator fuel pump does stop after 5 miniutes but there’s no difference to the engine trying to start
 
Have you checked the actual fuel quantity and pressure at the fuel regulator from the pump?

Cheers
 
neilly said:
Have you checked the actual fuel quantity and pressure at the fuel regulator from the pump?

Cheers
Click to expand...
I put fresh diesel in it and whilst I cranked it my mate put the diesel pipe in a bottle and it was in good nick but haven’t tested the pressure
 
How much output did you get when you cranked it, it could the LP side of the pump running.
 
neilly said:
How much output did you get when you cranked it, it could the LP side of the pump running.
Click to expand...
No idea I was just cranking will ask mate tomorrow I’ve been pressing throttle to try and purge with no luck don’t want to buy new parts without knowing what’s actually wrong the engine ran when it came from the disco but the defender had been sitting for four years before this
 
Evan farmer said:
It’s cranking over but it’s like it’s not getting fuel plenty of smoke and diesel leaking from the regulator and hissing noise from the regulator fuel pump does stop after 5 miniutes but there’s no difference to the engine trying to start
Click to expand...
try loosening the fuel line at the front of the cylinder head then prime to make sure fuel is actually going into the head and not just bypassing in side the regulator it could be possible the small oring that sits inside the head had falling off when changing the regulator this may create the regulator to by pass straight to the return

if you can hear it hissing could be air in the system still or its pulling in air from somewhere ..also fuel pressure gauge would be good to make sure the correct rating of regulator is installed I have experienced low pressure issues on some cheep regulators sold on ebay and they bypass sooner ...the air in the system is just going around around and around regardless how good the air bleed valve is

I also have to ask does the engine start on spray into the air intake

if the defender has been sitting for years make sure the fuel system is clean and free of water ....start at the fuel filter drain into a clean bowl and let it settle
drain fuel tank and clean take not of water in the fuel system from condensation also check fuel cap by cracking it off the fuel tank could possibly be in a vacuum
 
ozzyboydeano said:
try loosening the fuel line at the front of the cylinder head then prime to make sure fuel is actually going into the head and not just bypassing in side the regulator it could be possible the small oring that sits inside the head had falling off when changing the regulator this may create the regulator to by pass straight to the return

if you can hear it hissing could be air in the system still or its pulling in air from somewhere ..also fuel pressure gauge would be good to make sure the correct rating of regulator is installed I have experienced low pressure issues on some cheep regulators sold on ebay and they bypass sooner ...the air in the system is just going around around and around regardless how good the air bleed valve is

I also have to ask does the engine start on spray into the air intake

if the defender has been sitting for years make sure the fuel system is clean and free of water ....start at the fuel filter drain into a clean bowl and let it settle
drain fuel tank and clean take not of water in the fuel system from condensation also check fuel cap by cracking it off the fuel tank could possibly be in a vacuum
Click to expand...
Fuel is coming from the pipe into the cylinder head no idea what pressure though and runs on easy start and fuel is clean and have opened cap to put diesel in
 
Evan farmer said:
Fuel is coming from the pipe into the cylinder head no idea what pressure though and runs on easy start and fuel is clean and have opened cap to put diesel in
Click to expand...
you need to make sure that fuel is going into the head and not just the pipe leading to the head ..the front of the head is the return
 
You must log in or register to reply here.

Similar threads

T
300 Tdi auto discovery
Replies
15
Views
867
talbotracer
T
O
Series 3 Series 3 2.5 diesel Not Starting
Replies
8
Views
841
Bobsticle
Bobsticle
S
Starting issue. Fuel system bleed
Replies
8
Views
1K
sjr202
S
T
Frelander 1 bad starting and no power
Replies
2
Views
464
Freddie17
Freddie17
cappers
3.5 hotwire efi won't start - solved, poor connection to coil -ve!
Replies
14
Views
1K
AllanWorms
AllanWorms